Safety Data Sheet Regulation EC No 1907/2006 Art.31
Productname : SUPER TAPPING FLUID II Creationdate : 29.06.17 Version : 3.0
Ref.Nr.: BDS000781_3_20170629 (EN) Replaces: BDS000781_20170104
 
SECTION 1: Identification of the substance/mixture and of the company/undertaking
 
1.1. Product identifier
 
 
SUPER TAPPING FLUID II
Aerosol
 
1.2. Relevant identified uses of the substance or mixture and uses advised against
 
Lubricants
 
1.3. Details of the supplier of the safety data sheet
 
 
CRC Industries Europe bvba
Touwslagerstraat 1
9240 Zele
Belgium
Tel.: +32(0)52/45.60.11
Fax.: +32(0)52/45.00.34
E-mail : hse@crcind.com
 
SubsidiariesTelFax
CRC Industries Finland OyLaurinkatu 57 A 23 B, 08100 Lohja+358/(19)32.921
CRC Industries France6, avenue du marais, C.S. 90028, 95102 Argenteuil Cedex01.34.11.20.0001.34.11.09.96
CRC Industries Deutschland GmbHSüdring 9, D-76473 Iffezheim(07229) 303 0(07229)30 32 66
CRC INDUSTRIES IBERIA S.L.U.GREMIO DEL CUERO-PARC.96, POLIGONO INDUSTR. DE HONTORIA, 40195 SEGOVIA0034/921.427.5460034/921.436.270
CRC Industries SwedenLaxfiskevägen 16, 433 38 Partille0046/31 706 84 800046/31 27 39 91
 
1.4. Emergency telephone number
 
 
CRC Industries Europe, Belgium: Tel.: +32(0)52/45.60.11 (office hours: 9-17h pm CET)
 
SECTION 2: Hazards identification
 
2.1. Classification of the substance or mixture
 
Classification according to Regulation (EC) No 1272/2008
 
Physical: Aerosol, category 2
 Flammable aerosol.
 Pressurised container: May burst if heated.
Classification is based on test data.
Health: Not classified
Classification based on calculation method.
Environment: Not classified
Classification based on calculation method.
 
2.2. Label elements
 
Labelling according to Regulation (EC) No 1272/2008
 
Hazard pictogram(s):      
Signal word: Warning
Hazard statement(s): H223 : Flammable aerosol.
 H229 : Pressurised container: May burst if heated.
Precautionary statement(s): P102 : Keep out of reach of children.
P210 : Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking.
 P211 : Do not spray on an open flame or other ignition source.
 P251 : Do not pierce or burn, even after use.
P410/412 : Protect from sunlight. Do not expose to temperatures exceeding 50°C/122°F.
Supplemental Hazard information: Contains fluorinated greenhouse gases:
 HFC-134a
 quantity expressed in weight and CO2 equivalent depend on actual volume of the packaging: see label
GWP mixture: see section 12.6
 
2.3. Other hazards
 
No information available
 
SECTION 3: Composition/information on ingredients
 
3.1. Substances
 
Not applicable.
 
3.2. Mixtures
 
 
Hazardous ingredientRegistration numberCAS-nr.EC-nrw/w %Hazard Class and CategoryHazard statementNotes
mineral oil (IP 346 DMSO extract < 3%)---<85--B
tetrafluoroethane01-2119459374-33811-97-2212-377-05-10Press. GasH280B
polysulfides, di-tert-dodecyl01-2119540516-4168425-15-0270-335-70-5Aquatic Chronic 4H413
carbon dioxide-124-38-9204-696-90-1Press. GasH280A,G
Explanation notes
A : substance with Community workplace exposure limit
B : substance with national established workplace exposure limit
G : exempted from the obligation to register in accordance with art.2(7)of REACH Regulation No 1907/2006
(* Explanation phrases : see chapter 16)
 
SECTION 4: First aid measures
 
4.1. Description of first aid measures
 
Contact with eyes : If substance has got into eyes, immediately wash out with plenty of water
 If eye irritation persists: Get medical advice/attention.
Contact with skin : Take off contaminated clothing and wash before reuse.
 IF ON SKIN: Wash with plenty of water.
 If skin irritation occurs: Get medical advice/attention.
Inhalation : IF INHALED: Remove person to fresh air and keep comfortable for breathing.
 Call a POISON CENTER or doctor/physician if you feel unwell.
Ingestion : If swallowed accidentally, do not induce vomiting and seek medical advice.
 
 
4.2. Most important symptoms and effects, both acute and delayed
 
Inhalation : Excessive inhalation of solvent vapours may give rise to nausea, headaches and dizziness
Ingestion : May cause gastrointestinal disturbances
 Symptoms : sore throat, abdominal pain, nausea, vomiting
Skin contact : May cause irritation.
 Symptoms : redness and pain
Eye contact : May cause irritation.
 Symptoms : redness and pain
 
4.3. Indication of any immediate medical attention and special treatment needed
 
General Advice : If you feel unwell, seek medical advice (show the label where possible
 If symptoms persist always call a doctor
 
SECTION 5: Firefighting measures
 
5.1. Extinguishing media
 
foam, carbon dioxide or dry agent
 
5.2. Special hazards arising from the substance or mixture
 
Aerosols may explode if heated above 50°C
Forms hazardous decomposition products
CO,CO2
HF may be formed
 
5.3. Advice for firefighters
 
Keep container(s) exposed to fire cool, by spraying with water
In case of fire, do not breathe fumes
 
SECTION 6: Accidental release measures
 
6.1. Personal precautions, protective equipment and emergency procedures
 
Shut off all ignition sources
Ensure adequate ventilation
Wear suitable protective clothing and gloves.
 
6.2. Environmental precautions
 
Do not allow to enter public sewers and watercourses
If polluted water reaches drainage systems or water courses, immediately inform appropriate authorities
 
6.3. Methods and material for containment and cleaning up
 
Absorb spillage in suitable inert material
Place in appropriate container
 
6.4. Reference to other sections
 
For further information see section 8
 
SECTION 7: Handling and storage
 
7.1. Precautions for safe handling
 
Keep away from heat and sources of ignition
Take precautionary measures against static discharges
Equipment should be earthed
Use explosion-proof electrical/ventilating/lighting/.../equipment.
Use only non-sparking tools.
Do not breathe aerosols or vapours.
Ensure adequate ventilation
Avoid contact with skin and eyes.
Wash thoroughly after use
Wear protective gloves/protective clothing/eye protection/face protection.
 
7.2. Conditions for safe storage, including any incompatibilities
 
Pressurized container : protect from sunlight and do not expose to temperatures exceeding 50°C.
Keep in a cool, dry, well ventilated place
Keep out of reach of children.
 
7.3. Specific end use(s)
 
Lubricants
 
SECTION 8: Exposure controls/personal protection
 
8.1. Control parameters
 
Exposure limits :
 
 
Hazardous ingredientCAS-nr.method
EU established exposure limits:
carbon dioxide124-38-9TWA9000 mg/m3
STEL1800 mg/m3
National established exposure limits, United Kingdom
carbon dioxide124-38-9TWA5000 ppm
STEL15000 ppm
tetrafluoroethane811-97-2TWA1000 ppm
 
8.2. Exposure controls
 
Control procedures : Ensure adequate ventilation
 Keep away from heat and sources of ignition
 Take precautionary measures against static discharges
Personal protection : Take precautions to avoid contact with skin and eyes when handling the product.
 Ensure adequate ventilation
inhalation : In case of insufficient ventilation, wear suitable respiratory equipment.
recommended respiratory protection: Air purifying respirator equiped with organic gas/vapor cartridge (type A)
hands and skin : When handling the product wear chemical-resistant gloves (standard EN 374).
 Use a reusable glove with a minimum breakthrough time of 30 minutes. The breakthrough time of the glove should be longer than the total duration of product use. If work lasts longer than the breakthrough time, gloves should be changed part-way through.
Recommended gloves: (neoprene)
eyes : Wear safety eyewear according to EN 166.
Environmental protection: Avoid release to the environment.
 Collect spillage.
Consumer exposure protection: Do not eat, drink or smoke when using this product.
 Use only outdoors or in a well-ventilated area.
 IF exposed or if you feel unwell: Call a POISON CENTER or doctor/physician.
 
SECTION 9: Physical and chemical properties
 
9.1. Information on basic physical and chemical properties
 
(for aerosols data for the product without propellant)
Appearance : physical state : Liquid under pressure.
colour : Green.
odour : Characteristic odor.
pH : Not applicable.
Boiling point/range : Not available.
Flash point : > 150 °C
Evaporation rate : Not applicable.
Explosion limits : upper limit : Not available.
lower limit : Not available.
Vapour pressure : Not available.
Relative density : 0.875 g/cm3 (@ 20°C).
Solubility in water : Insoluble in water
Auto-ignition : > 200 °C
Viscosity : 25.84 mPa.s (@ 40°C).
 
9.2. Other information
 
VOC = volatile organic compounds 50 g/l
 
SECTION 10: Stability and reactivity
 
10.1. Reactivity
 
No hazardous reactions known if used for its intended purpose
 
10.2. Chemical stability
 
Stable
 
10.3. Possibility of hazardous reactions
 
No hazardous reactions known if used for its intended purpose
 
10.4. Conditions to avoid
 
Avoid overheating
 
10.5. Incompatible materials
 
Strong oxidising agent
 
10.6. Hazardous decomposition products
 
CO,CO2
HF may be formed
 
SECTION 11: Toxicological information
 
11.1. Information on toxicological effects
 
acute toxicity: based on available data the classification criteria are not met
skin corrosion/irritation: based on available data the classification criteria are not met
serious eye damage/irritation: based on available data the classification criteria are not met
respiratory or skin sensitisation: based on available data the classification criteria are not met
germ cell mutagenicity: based on available data the classification criteria are not met
carcinogenicity: based on available data the classification criteria are not met
toxicity for reproduction: based on available data the classification criteria are not met
STOT-single exposure: based on available data the classification criteria are not met
STOT repeated exposure: based on available data the classification criteria are not met
aspiration hazard: based on available data the classification criteria are not met
 
Information on likely routes of exposure:
 
Inhalation : Inhalation of solvent vapours may give rise to nausea, headaches and dizziness
Ingestion : May cause gastrointestinal disturbances
Skin contact : Prolonged skin contact will result in defatting of the skin, leading to irritation, and in some cases, dermatitis
 Repeated exposure may cause skin dryness or cracking.
Eye contact : May cause irritation.
 
Toxicological data :
 
 
Hazardous ingredientCAS-nr.method
tetrafluoroethane811-97-2LC50 inhal.rat567000 ppm
 
SECTION 12: Ecological information
 
12.1. Toxicity
 
Not classified
 
Ecotoxicological data:
 
 
Hazardous ingredientCAS-nr.method
tetrafluoroethane811-97-2LC50 fish450 mg/l
EC50 daphnia980 mg/l
 
12.2. Persistence and degradability
 
No experimental data available
 
12.3. Bioaccumulative potential
 
No experimental data available
 
12.4. Mobility in soil
 
Insoluble in water
 
12.5. Results of PBT and vPvB assessment
 
No information available
 
12.6. Endocrine disrupting properties
 
No experimental data available
GWP (global warming potential): 80
(calculated in accordance with Annex IV of Regulation (EU) No 517/2014 on fluorinated greenhouse gases)
 
SECTION 13: Disposal considerations
 
13.1. Waste treatment methods
 
Product : This material and its container must be disposed of in a safe way.
 Do not discharge into drains or the environment, dispose to an authorised waste collection point.
Contaminated packaging : Disposal should be in accordance with local, state or national legislation
 
SECTION 14: Transport information
 
14.1. UN number
 
UN-number : 1950
 
14.2. UN proper shipping name
 
Proper shipping name: AEROSOLS
 
14.3. Transport hazard class(es)
 
Class: 2.1
ADR/RID - Classification code: 5F
 
14.4. Packing group
 
Packing group: Not applicable.
 
14.5. Environmental hazards
 
ADR/RID - Environmentally hazardous: No
IMDG - Marine pollutant: No
IATA/ICAO - Environmentally hazardous: No
 
14.6. Special precautions for user
 
ADR/RID - Tunnelcode: (D)
IMDG - Ems: F-D, S-U
IATA/ICAO - PAX: 203
IATA/ICAO - CAO 203
 
14.7. Maritime transport in bulk according to IMO instruments
 
Not applicable.
 
SECTION 15: Regulatory information
 
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
 
The Safety Data Sheet is compiled according to the current European requirements.
Regulation (EC) No 1907/2006 (REACH)
Regulation (EC) No 1272/2008 (CLP)
Dir. 2013/10/EU, 2008/47/EC amendment of the aerosol dispenser directive 75/324/EEC.
 
15.2. Chemical safety assessment
 
No information available
 
SECTION 16: Other information
 
*Explanation hazard statements: - : -
 H280 : Contains gas under pressure; may explode if heated.
 H413 : May cause long lasting harmful effects to aquatic life.
REVISIONS IN CHAPTRE : Labelling according to Regulation (EC) No 1272/2008
 8.2. Exposure controls
acronyms and synonyms: TWA = time weight average
 STEL = short time exposure limit
 VOC = volatile organic compounds
 PBT = persistant bioaccumulative toxic
 vPvB = very persitant very bioaccumulative
This product should be stored, handled and used in accordance with good industrial hygiene practices and in conformity with any legal regulation.
The information contained herewith is based on the present state of our knowledge and is intended to describe our products from the point of view of safety requirements. It does not guarantee any specific properties.
Apart from any fair dealing for purposes of study, research and review of health, safety and environmental risks,no part of these documents may be reproduced by any process without written permission from CRC.